NFPA Hazard Ratings:

0=Minimal, 1=Slight, 2=Moderate, 3=Serious, 4=Severe

Emergency Overview: Caution: Eye and skin irritant

Potential Health Effects:

• Signs and Symptoms of Acute Overexposure: Contact may cause irritation to eyes, skin, respiratory tract, mucous membranes.
• Signs and Symptoms of Chronic overexposure:.NDA
• Medical Conditions Generally Aggravated by Exposure: None known.

• Inhalation: Remove victim to fresh air. Get prompt medical attention.
• Ingestion: Do not induce vomiting. Give water or fruit juice to drink. Get prompt medical attention
• Skin Contact: Wash skin with water for at least 15 minutes, until slipperiness is gone. Remove contaminated clothing and launder before reuse. Get medical attention if skin is burned or if irritation persists.
• Eye Contact: Immediately flush eyes with water for 15 minutes. Get medical attention.
• Note to Physician: Treat symptomatically and supportively.

Flash Point: None by PMCC

Flammability Limits: NDA

Autoignition temp: NDA

Fire Extinguishing Media: Suitable for surrounding fire.

Special Fire-Fighting Information: Wear NIOSH-approved SCNA. Use water spray to cool containers and to knock down fumes.

Unusual Fire and Explosion Hazards: NDA

• Ventilation System: Good general ventilation is advisable
• Personal Respirators (NIOSH or EIN Approved): None required during normal handling.
• Skin Protection: Neoprene, rubber or PVC gloves, boots and apron. Body covering clothing
• Eye Protection: Chemical safety goggles, full face shield
• Other Control Measures:

  OSHA - PEL: CAS 7631-95-0: 5 mg/m3 for soluble molybdenum compounds

  ACGIH: CAS 7631-95-0: 5 mg/m3 for soluble molybdenum compounds

• Appearance and Color: Nearly Colorless liquid.
• Odor: Low odor
• Solubility in Water: Miscible
• Specific Gravity: 1.08
• pH: 7.5 - 8.5
• % volatile by volume @ 21C (70F): NDA
• Boiling Point: 212 degrees F/ 100 degrees C
• Melting Point: NDA
• Vapor Density (Air=1): NDA
• Vapor Pressure (mm Hg): NDA
• Evaporation Rate (Bu. Acetate=1): NDA

• Stability: Product is stable under normal conditions
• Hazardous Decomposition Products: Oxides of carbon and nitrogen
• Hazardous Polymerization: will not occur.
• Incompatibility: none
• Conditions to Avoid: none

• Toxicological Data:

RTECS: CAS# 7732-18-5: ZC0110000 / CAS# 7632-00-0: RA1225000 / CAS# 7631-95-0: QA5075000 / CAS# 25155-30-0:DB6825000 /CAS# 27176-87-0: DB6600000 / CAS# 27176-87-0: DB6600000

 

LD/LC50:  CAS# 7732-18-5: LD50= >90 mL/Kg / CAS# 7632-00-0: Oral, mouse: LD50 = 175 mg/kg; Oral, rabbit: LD50 = 186 mg/kg; Oral, rat: LD50 = 85 mg/kg. / CAS# 7631-95-0: Oral, rat LD50 = 4 g/Kg / CAS# 25155-30-0: Acute Oral Rat, LD50 1260 mg/Kg; Oral, mouse > 2,000 mg/Kg / CAS# 27176-87-0: Oral, rat LD50 = 650 mg/Kg
 

• Carcinogenicity:

ACGIH-A3 - Molybdenum soluble compounds (sodium or ammonium) is listed on the "confirmed animal carcinogen list," but is NOT listed by IARC, NIOSH, NTP or OSHA lists.
Other ingredients are NOT found on any lists published by ACGIH, IARC, NIOSH, NTP or OSHA

Environmental Fate: Ingredients are NOT expected to bioconcentrate

Environmental Toxicity: CAS 7632-00-0 is not expected to cause oxygen depletion in aquatic systems, It has a high potential to affect secondary waste treatment organisms. It has a low potential to affect the germination of some plants. Acute aquatic effects: 96 hour LC50; fathead minnow: GT 100 mg/L 96 hour LC50; Water flea: 55 mg/L 24 hour LC50; Mosquito fish: 8.1 mg/L.

• DOT Proper Shipping Name: Boiler and cooling water preserving compounds - unregulated
• DOT Hazard Class: none
• UN Number: none
• Packing Group: none
• DOT Label: : "Class35 : Boiler and cooling preserving compounds - unregulated

• TSCA: (40CFR 710) All chemical ingredients are listed on the TSCA 8(b) inventory. None of the ingredients are on the Health and Safety Reporting List, are under Chemical Test rule, are listed under TSCA Section 12B, or have a SNUR under TSCA
• CERCLA Reportable Quantity: This product contains 100 lbs. of sodium nitrite that has a Reportable Quantity (RQ) requirements of 100 lbs.(approx.924 gallons of this formula), under US 40 CFR 117.302.
• SARA TITLE III:

..................................Section 302/304 Extremely Hazardous Substances: NDA

..................................Section 311 Hazard Categorization: Acute Health

..................................Section 313 Toxic Chemicals: None

• Clean Water Act: No ingredients listed as a hazardous substance under the CWA. None of the chemicals in this formula are listed as Priority Pollutants under CWA
• Clean Air Act: No ingredients listed as a hazardous air pollutant (HAP). This product does not contain any Class 1 or Class 2 ozone depletors, nor was it made with such chemicals
• OSHA: None of the ingredients are listed as "Highly Hazardous" by OSHA.
• STATE-RIGHT-TO-KNOW LISTS: : Sodium dodecylbenzene sulfonic acid, CAS# 25155-30-0, representing 1% of this formula IS is listed on the California, New Jersey, Pennsylvania, Minnesota & Massachusetts RTK lists. Other ingredients are NOT listed on any of the following state right to know lists: California, Connecticut, Florida, Illinois, Louisiana, Maine, Maryland,Massachusetts, Minnesota, New Jersey, New York, Pennsylvania, Rhode Island or Tennessee.
• Not subject to California Proposition 65 labeling requirements
• State Spill RQ: As D002 waste; Louisiana spill RQ=111 lbs, Massachussetts spill RQ=111 lb, New Jersey has a tax for disposal, Connecticut has a survey, and Illinois has a chem.report required.
• Canadian DSL All ingredients are listed on Canada's DSL List. Product is approved for sale in Canada
• Canadian WHMIS: This product does not have a WHMIS classification
• Canada's Ingredient Disclosure List: Ingredients are "NOT CONTROLLED". . This MSDS has been prepared according to the hazard criteria of the Controlled Products Regulations (CPR) and the MSDS contains all of the information required by the CPR.
• European Labeling in Accordance with EC Directives: Directives:CAS# 7632-00-0 -European Labeling in Accordance with EC Directives Hazard Symbols: TO XI Risk Phrases: R 25 Toxic if swallowed. R 8 Contact with combustible material may cause fire.R 36/37/38 Irritating to eyes, respiratory system and skin. Safety Phrases: S 45 In case of accident of if you feel unwell, seek medical advice immediately (show the label where possible.
• Other Countries Exposure Limits: CAS# 7632-00-0:. OEL-CZECHOSLOVAKIA:TWA 1 mg/m3;STEL 5 mg/m3. OEL-HUN GARY:STEL 1 mg/m3;Skin

Reason for Revision: Routine review and revision

Alken-Murray Corporation provides the information contained herein in good faith, in compliance with the Occupational Safety and Health Act of 1970, but makes no representation as to its comprehensiveness or accuracy. This document is intended only as a guide to the appropriate precautionary handling of the material by a properly trained person using this product. Alken-Murray warrants that this product is of merchantable quality. The implied warranty of fitness for a particular purpose is limited to the extent the products are used for the purpose or uses described on the product's label or in any written instructions or materials distributed to the buyer by Alken-Murray and is hereby disclaimed should buyer use the products in a manner inconsistent with this uses or purposes described therein. In no event shall Alken-Murray be liable for any consequential, exemplary, or incidental damages incurred by buyer even if it has been advised of the possibility of such damages.