Signs and Symptoms of
Acute Overexposure: Eye,
skin irritation. Inhalation of heated vapors may irritate the respiratory
Signs and Symptoms of
Chronic overexposure: Prolonged
inhalation of concentrated.heated vapors may cause damage to the kidneys.
Reddening and swelling of affected area with possile itching, burning or
Medical Conditions Generally
Aggravated by Exposure:
Existing cuts, rashes, allergies, or other sensitive areas.
Ingestion: Ingestion may result in abdominal pain,
nausea, and vomiting.
4. First Aid Measures
Inhalation: Remove victim to fresh air
Ingestion: Give victim water or milk to drink to dilute
the product. Get medical advice..
Skin Contact: Remove contaminated clothing and footwear.
Wash skin with soap and water. Wash clothing before reuse.
Eye Contact: Immediately flush eyes with water for
15 minutes. Get medical attention.
Note to Physician: None
5. Fire Fighting Measures
Flash Point: > 200 degrees F (PMCC)
Flammability Limits: NDA
Autoignition temp: NDA
Fire Extinguishing Media: Any available extinguishing including water
spray, carbon dioxide, dry chemical, Halon 1211
Special Fire-Fighting Information:
Spilled chemical creates
extremely slippery conditions, especially in contact with water. Use caution.
Respiratory and eye protection are reqyired. Petroleum component is combustible,
if separated from other ingredients. Vapors/fumes will ignite.
Unusual Fire and Explosion
components are combustible if separated from the emulsion.
6. Accidental Release Measures
Remove sources of ignition. Contain
and collect, using a suitable absorbent, if needed. Place into suitable
container(s) for disposal. Thoruhgly flush residuals to drain, as spilled
product creates extremely slippery conditions.
7. Handling and Storage
Handle as an irritant. Do not
get in eyes. Avoid prolonged/repeated skin contact. Do not inhale vapors/mists.
Do not ingest. Store away from sources of ignition. Spilled product creates
very slippery condition, especially in contact with water.
8. Exposure Controls/ Personal Protection
Ventilation System: Good general ventilation is advisable.
Local exhaust desired.
Personal Respirators (NIOSH
Approved): None required
for normal use and processes. if needed, use respirator to filter out mists/vapors.
Skin Protection: Long sleeved clothing, impervious rubber
or neoprene gloves and protective apron.
Eye Protection: Safety glasses or goggles
Other Control Measures:
in accordance with good hygiene practice. Avoid handling which would create
large amounts of mists/vapors. Exxon Medical Research recommended inhalation
TLV for CAS 64742-47-8 of 200 ppm.
RCRA Hazard Class (if
discarded): Neat, unused
product is not considered a hazardous waste, according to RCRA regulations
40 CFR 261. . For proper disposal of used materials, an assessment must
be completed to determine the proper waste management options permissible
under applicable rules, regulations and/or laws governing client's location.
Use until less than 1 inch remains in the container, triple rinse with clean
water, and pour rinse water to sewer. Then remove or deface product label
to avoid confusion if pail or drum is later refilled. Clean, empty containers
should be recycled or disposed of through an approved waste management facility.
14. Transportation Information
DOT Proper Shipping Name: Not regulated as hazardous by DOT or Canadian
DOT Hazard Class: None
DOT Label: Class 60:(NMFC item #4612, LTL) "adhesives,
adjuvents, spreaders, sliders, liquid, in pails or drums" Alken Solutions
A4040L, anionic acrylamide polymer liquid
15. Regulatory Information
TSCA: : (40CFR 710) All chemical ingredients
are listed on the TSCA 8(b) inventory. None of the ingredients are on the
Health and Safety Reporting List, are under Chemical Test rule, are listed
under TSCA Section 12B, or have a SNUR under TSCA CERCLA Reportable Quantity: Not subject to CERCLA reporting
Clean Water Act: None of the chemicals in this formula are
listed as Priority Pollutants under CWA.
Clean Air Act : Ingredients not listed as hazardous pollutants
under CAA. This product does not contain any Class 1 or Class 2 ozone depletors,
nor was it made with such chemicals.
OSHA: None of the ingredients are considered Extremely
Hazardous by OSHA.
STATE RIGHT-TO-KNOW LAWS:. Ingredients not listed on California,
Connecticut, Florida, Illinois, Louisiana, Massachusetts, New Jersey, New
York, Pennsylvania, or Rhode Island.
Not subject to California Proposition
65 labeling requirements
Canadian WHMIS Classification:
CAS 64742-47-8: B3. Combustible
Liquid, but flash point of formulated product has a flash pint above flammable-combustible
limit for Canada
Canadian DSL: all ingredients listed and compliant
Canada's Ingredient Disclosure
List:Light hydrotreated kerosine solvent CAS#
64742-47-8, comprising 25% of this product IS listed on the CIDL, but other ingredients are "NOT CONTROLLED".
This MSDS has been prepared according to the hazard criteria of the Controlled
Products Regulations (CPR) and the MSDS contains all of the information
required by the CPR.
TDG Classification: Not regulated as hazardous by Canadian
IHT Codes: 3906.90.5000
16. Other Information
Reason for Revision: Routine review & revision
provides the information contained herein in good faith, in compliance with
the Occupational Safety and Health Act of 1970, but makes no representation
as to its comprehensiveness or accuracy. This document is intended only
as a guide to the appropriate precautionary handling of the material by
a properly trained person using this product. Alken-Murray warrants that
this product is of merchantable quality. The implied warranty of fitness
for a particular purpose is limited to the extent the products are used
for the purpose or uses described on the product's label or in any written
instructions or materials distributed to the buyer by Alken-Murray and is
hereby disclaimed should buyer use the products in a manner inconsistent
with this uses or purposes described therein. In no event shall Alken-Murray
be liable for any consequential, exemplary, or incidental damages incurred
by buyer even if it has been advised of the possibility of such damages.